Back in the early 60's when I was an apprentice all new blocks were sprayed with lacquer sealer before and after drilling. That was at Aeolian Co. of MO James Grebe Piano-Forte Tuning & Repair Creator of Handsome Hardwood Caster Cups (314) 608-4137 WWW.JamesGrebe.com 1526 Raspberry Lane Arnold, MO 63010 BECOME WHAT YOU BELIEVE! pianoman@accessus.net ----- Original Message ----- From: "gordon stelter" <lclgcnp@yahoo.com> To: "Pianotech" <pianotech@ptg.org> Sent: Saturday, October 30, 2004 12:27 PM Subject: Re: Cracked Lid > Evaporation of volatile components. Bacterial decay. ( > See J.Garret's post about brittle action parts. ) > Granted this would be less a factor in a veneered and > sealed component. But a definite possibility, I > think. > You have probably observed how many open-faced > blocks are in better shape than their covered > counterparts? I think this has a lot to do with the > varnish on them. Perhaps we should varnish our new > blocks befor installing? > ( If we believe in doing top-notch work, vs. planned > obsolescnce, that is, as do I! ) > Thump > > > --- Farrell <mfarrel2@tampabay.rr.com> wrote: > >> How would it loose density/mass over time? >> >> Terry Farrell >> >> ----- Original Message ----- >> From: "gordon stelter" <lclgcnp@yahoo.com> >> To: "Pianotech" <pianotech@ptg.org> >> Sent: Saturday, October 30, 2004 12:58 PM >> Subject: Re: Cracked Lid >> >> >> > Could the Oak or Ash also seem less dense just >> because >> > it was from well-aged large logs, sitting in a >> piano >> > for 100 years? >> > Thump >> > >> > >> > --- Farrell <mfarrel2@tampabay.rr.com> wrote: >> > >> > > I don't remember chestnut very well from my wood >> > > technology class - I'm sure >> > > I had to memorize it's properties at some point. >> But >> > > I have cut up a number >> > > of vertical pianos and the core wood was not >> poplar. >> > > It looked a lot more >> > > like oak or ash, but clearly seemed less dense. >> Do >> > > you know offhand whether >> > > chestnut is less dense than oak and ash (both of >> > > which are darn dense!). >> > > >> > > Terry Farrell >> > > >> > > ----- Original Message ----- >> > > From: "Ron Nossaman" <rnossaman@cox.net> >> > > To: "Pianotech" <pianotech@ptg.org> >> > > Sent: Saturday, October 30, 2004 12:46 PM >> > > Subject: RE: Cracked Lid >> > > >> > > >> > > > >> > > > >Good thoughts. >> > > > >I think the problem with this particular lid >> (the >> > > Steinway I've >> > > mentioned) >> > > > >is the lack of cross banding. I' ve seen >> this >> > > omition before when I did >> > > a >> > > > >lot of furniture repair in another life. >> Also, >> > > the oak core tends to >> > > move >> > > > >more, ends being the worst. >> > > > > >> > > > >Paul C >> > > > > >> > > > > Paul >> > > > > I agree about the cross banding thought. >> Stwys >> > > are poplar which is >> > > more >> > > > > stable than oak IMO. >> > > > >> > > > >> > > > Chestnut was a common furniture core wood too, >> and >> > > looks a lot like oak or >> > > > ash. It's more dimensionally stabile than >> either, >> > > which is why it was used >> > > > so much under veneers. For what it's worth. >> > > > >> > > > Ron N >> > > > >> > > > >> _______________________________________________ >> > > > pianotech list info: >> > > https://www.moypiano.com/resources/#archives >> > > > >> > > >> > > >> > > _______________________________________________ >> > > pianotech list info: >> > > https://www.moypiano.com/resources/#archives >> > > >> > >> > >> > >> > >> > __________________________________ >> > Do you Yahoo!? >> > Yahoo! Mail Address AutoComplete - You start. We >> finish. >> > http://promotions.yahoo.com/new_mail >> > _______________________________________________ >> > pianotech list info: >> https://www.moypiano.com/resources/#archives >> > >> >> _______________________________________________ >> pianotech list info: >> https://www.moypiano.com/resources/#archives >> > > > > > __________________________________ > Do you Yahoo!? > Read only the mail you want - Yahoo! Mail SpamGuard. > http://promotions.yahoo.com/new_mail > _______________________________________________ > pianotech list info: https://www.moypiano.com/resources/#archives
This PTG archive page provided courtesy of Moy Piano Service, LLC